1996 – 2004 Mustang Technical Service Bulletins

Technical Service Bulletin ID

Description

00-04-02

VIBRATION/SHAKE—AT STEADY SPEED APPROXIMATELY 100 KM/H (62 MPH)— VEHICLES WITH 3.8L ENGINE AND CONVERTIBLE TOP

00-09-01

LEAK—TRANSMISSION FLUID LEAKS AT RADIATOR—VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR END TANK

00-09-04

NOISE—“POPPING/CLUNKING” HEARD WHILE PERFORMING A QUICK LANE CHANGE AT HIGHWAY SPEEDS AND/OR GOING UP AN INCLINE AT LOW SPEEDS—COBRA VEHICLES ONLY (DOES NOTINCLUDE COBRA R VEHICLES)

00-09-06

WINDSHIELD WIPERS—FRONT WIPERS OPERATE WHILE SWITCH IS IN “OFF” POSITION

00-09-07

VIBRATION/SHAKE—AT STEADY SPEED APPROXIMATELY 100 KM/H (62 MPH)—VEHICLES WITH 4.6L ENGINE AND CONVERTIBLE TOP

00-18-03

COOLING SYSTEM—COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD—VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000—VEHICLES WITH 4.6L 2V OR 5.4L 2V ENGINE

ENGINE—4.6L 2V OR 5.4L 2V—COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD—VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000

00-21-02

HOOD—HOOD REQUIRES EXCESSIVE EFFORT TO CLOSE—SERVICE TIPS

00-23-10

TRANSMISSION—FLUID IN-LINE FILTER KIT—REPEAT REPAIRS OF TRANSMISSION—SERVICE TIPS

01-01-09

DRIVEABILITY—HESITATION WHEN COLD—WITH NO DIAGNOSTIC TROUBLE CODES (DTC) PRESENT—VEHICLES EQUIPPED WITH 4.6L ENGINE AND MANUAL TRANSMISSION

01-04-08

ENGINE—3.8L—OIL PUMP LIQUID INJECTION SEAL (LIS) GASKET SERVICE PROCEDURE—MUSTANG VEHICLES EQUIPPED WITH 3.8L ENGINE—VEHICLES PRODUCED 11/27/2000 THROUGH 6/30/2001—SERVICE TIPS

01-05-08

NOISE—“TICKING” OR “CLICKING” FROM Article No.TRANSMISSION—HEARD IN 1ST GEAR ONLY—VEHICLES EQUIPPED WITH 4R70W AUTOMATIC TRANSMISSION ONLY

TRANSMISSION—4R70W—“TICKING” OR “CLICKING” NOISE FROM TRANSMISSION—HEARD IN 1ST GEAR ONLY—VEHICLES EQUIPPED WITH 4R70W AUTOMATIC TRANSMISSION ONLY

01-06-02

PASSIVE ANTI THEFT SYSTEM (PATS)—DIAGNOSTIC SERVICE TIPS

01-07-01

SUSPENSION—NOISE—“SQUEAK” FROM REAR SUSPENSION OVER BUMPS—COBRA MODELS ONLY

NOISE—“SQUEAK” FROM REAR SUSPENSIONOVER BUMPS—COBRA MODELS ONLY

01-08-03

VIBRATION—FELT THROUGH SEAT, FLOOR AND/OR STEERING WHEEL AT HIGHWAY SPEEDS WHILE IN 4TH OR 5TH GEAR—COBRA MODEL ONLY

01-09-07

DRIVEABILITY—HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS—SERVICE TIPS—OBD II VEHICLES ONLY

01-10-12

WIRING—WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE

01-12-03

DRIVEABILITY—DETONATION OR SPARK KNOCK ON HEAVY ACCELERATION—MUSTANG BULLITT GT VEHICLES ONLY

ENGINE—4.6L 2 VALVE—DETONATION OR SPARK KNOCK ON HEAVY ACCELERATION—MUSTANG BULLITT GT VEHICLES ONLY

01-13-07

NOISE—“CLUNK” NOISE HEARD ON 2-1 DOWNSHIFT VEHICLES EQUIPPED WITH 4R70W AUTOMATIC TRANSMISSION

TRANSMISSION—4R70W—“CLUNK” NOISE HEARDFROM TRANSMISSION ON 2-1 DOWNSHIFT

01-15-06

CLIMATE CONTROL—REPEAT HEATER CORE FAILURE

COOLING SYSTEM—REPEAT HEATER CORE FAILURE

01-17-04

BODY—HOOD SCOOP LOOSE OR DETACHED FROM HOOD

01-21-06

ELECTRICAL—REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH

01-21-10

ENGINE—4.6L—OIL LEAK FROM HEAD GASKET AREA—ROMEO BUILT ENGINES ONLY

01-21-13

DRIVEABILITY—DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY—STICKING OR BINDING IGNITION LOCK CYLINDER—HIGH EFFORT WHEN TURNING IGNITION SWITCH
ELECTRICAL—STICKING OR BINDING IGNITION
LOCK CYLINDER—HIGH EFFORT WHEN TURNING IGNITION SWITCH

01-23-05

TRANSMISSION—T-45 MANUAL TRANSMISSION—STUCK IN REVERSE—DIFFICULT TO SHIFT INTO REVERSE—POPS OUT OF REVERSE

01-24-06

ENGINE—ENGINE OIL SYSTEM PRIMING PROCEDURES—SERVICE TIPS

02-02-02

COOLANT—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER—VEHICLES EQUIPPED WITH 4.6L 2V ENGINE ONLY
ENGINE—4.6L 2V—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER

02-05-04

ENGINE—4.6L—FRONT END ACCESSORY DRIVE (FEAD) BELT SLIPS OFF WATER PUMP PULLEY WHEN SPLASHED WITH WATER

02-06-07

PAINT—MYSTIC COBRA—REPAIR MATERIAL REQUEST PROCESS—SVT MUSTANG COBRA ONLY

02-11-04

ENGINE—NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS

02-16-04

FUEL SYSTEM—FUEL PUMP “WHINING”/“BUZZING” NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER

RADIO—ENTERTAINMENT OR TWO-WAY COMMUNICATION—“WHINING”/“BUZZING” NOISEIN SPEAKERS CAUSED BY FUEL PUMP

NOISE—“WHINING”/“BUZZING”—COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO

02-17-02

ENGINE—OIL LEAK FROM POSITIVE CRANKCASE VENTILATION (PCV) VALVE AREA—VEHICLES BUILT BEFORE 5/17/2002 EQUIPPED WITH 4.6L 2V ENGINE ONLY

02-17-06

LAMP—BRAKE—INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK

02-17-08

NOISE—WIND NOISE FROM THE “A” PILLAR AREA

02-21-13

ENGINE—STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS

02-22-01

DRIVEABILITY—SURGE/ROLLING IDLE—GEAR DRIVEN SYNCHRONIZERS—INCORRECT INSTALLATION—CAMSHAFT POSITIONSYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION

ENGINE—GEAR DRIVEN SYNCHRONIZERS—INCORRECT INSTALLATION—CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION

02-23-03

DRIVEABILITY—FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED

ENGINE—3.0L/3.8L/4.6L—FUEL PRESSURE RELIEFVALVE (SCHRADER VALVE) DISCONTINUED

02-23-04

DIAGNOSTIC TROUBLE CODE (DTC)—P1635 AND/OR P1639 PRESENT AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENTCLUSTER REPLACEMENT—GASOLINE ENGINE VEHICLES ONLY

LAMP—4X4 LAMP ILLUMINATED AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT—GASOLINE ENGINE VEHICLES ONLY
SPEEDOMETER—INACCURATE AND/OR INOPERATIVE AFTER POWERTRAIN CONTROL
MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT—GASOLINE ENGINE VEHICLES ONLY

03-01-05

TRIM—PASSENGER SEAT RUBS AGAINST DOOR PANEL

03-03-06

SUSPENSION—DRIFT OR PULL TO RIGHT OR LEFT—MUSTANG COBRA MODELS ONLY

03-06-02

ENGINE—CYLINDER HEAD DECK LEAK—4.6 AND 5.4L ENGINES—NEW “SERVICE-ONLY” GASKET AND CYLINDER HEAD KITS AVAILABILITY

03-09-05

SUSPENSION—CLUNK OR POP NOISE FROM REAR SUSPENSION—MUSTANG COBRA ONLY—SERVICE TIPS

NOISE—CLUNK OR POP NOISE FROM REARSUSPENSION—MUSTANG COBRA ONLY—SERVICE TIPS

03-11-04

ENGINE—MUSTANG COBRA—TICK NOISE FROM

ENGINE—COBRA VEHICLES EQUIPPED WITH ENGINES BUILT BEFORE 11/1/2002 ONLY

03-18-01

ELECTRICAL—REMOTE KEYLESS ENTRY (RKE)—SERVICE TIPS

03-20-03

DRIVEABILITY—MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC’S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457

03-22-01

BODY—NOISE—HOOD SCOOP (SHAKER) RATTLE NOISE

ENGINE—NOISE—HOOD SCOOP (SHAKER) RATTLE NOISE

NOISE—HOOD SCOOP (SHAKER) RATTLE NOISE

03-23-02

BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

03-24-03

TRANSMISSION—AUTOMATIC TRANSMISSION GEAR SELECTOR LEVER STUCK IN PARK, UNABLE TO SHIFT INTO PARK—OVERDRIVE FUNCTION INOPERATIVE

03-25-05

PAINT—PIN HOLES AND/OR PAINT DELAMINATIONON VEHICLE HOOD—VEHICLES BUILT 6/1/2001 THROUGH 3/1/2003 ONLY

03-25-06

ENGINE—ROMEO BUILT 4.6L 2V—TICK NOISE FROM ENGINE—ENGINES BUILT BEFORE 9/17/2003

04-01-02

BODY—INTERIOR TRIM—HEADLINER SAGGING IN REAR

04-05-03

CLIMATE CONTROL—RATTLE NOISE FROM INSTRUMENT PANEL VENTS—DIFFICULT TO ADJUST

NOISE—CLIMATE CONTROL—RATTLE NOISEFROM INSTRUMENT PANEL VENTS—DIFFICULT TO ADJUST

04-11-01

DRIVEABILITY—STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MIL ON AND DTCS P0401, P0402, P1400 OR P1401—ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY

04-13-04

TRANSMISSION RATTLE NOISE OR DIFFICULT TO SHIFT—TREMEC T56 6 SPEED MANUAL

04-15-06

TR3650 MANUAL TRANSMISSION—JUMPS OUT OF GEAR 2ND AND/OR 3RD—CLASH NOISE AND/OR RASPY FEEL ON GEAR ENGAGEMENT

04-17-04

04-19-08

MANUAL TRANSMISSION HARD TO SHIFT INTO FIRST/REVERSE FROM A STOP

04-21-06

EXHAUST LEAK—CRACKED OR SEPARATED RIGHT SIDE EXHAUST PIPE—3.8L AND 3.9L ENGINES

04-24-03

LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

04-24-05

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

04-24-14

GENERAL PCM PROGRAMMING PROCEDURES

04-26-13

1-2 SHIFT CLASH, GRIND OR HARD TO SHIFT—TR3650 5 SPEED MANUAL TRANSMISSION

05-03-10

SAFETY BELT WEB STOP BUTTON SERVICE

05-09-03

INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

05-14-03

SQUEAK/CREAK NOISE FROM STEERING RACK WHEN TURNING

05-16-11

SAFETY BELT RETRACTION SPEED

05-22-08

WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

06-04-02

BATTERY SERVICE—OPERATION OF BATTERY EYE—CHARGING SERVICE TIPS

06-04-04

LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS

06-04-09

A/C COMPRESSOR NOT OPERATIONAL / LOW FREON—SHAFT SEAL LEAKS

06-05-13

ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE (DTC) P0301, P0302, P0303, P0304, P0305,P0306, P0307, P0308, AND P0316

06-08-05

SPEED CONTROL DIAGNOSTICS—W/O SCP

06-14-04

MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID

06-15-08

KEYPAD DIAGNOSTICS—DEALER INSTALLED ACCESSORY

06-18-16

IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

95-16-10

FLUID—NEW ROTUNDA FLUID CHANGER—SERVICE TIP

95-21-01

SUPPLEMENTAL RESTRAINT SYSTEM—AIR BAG MODULES—DISCOLORED OR MARRED COVERS—PAINTING RESTRICTIONS

96-03-14

NOISE—LIGHT “CLICKING” AND/OR “GRINDING” NOISE—VEHICLES BUILT FROM 8/11/95 THROUGH 9/25/95 WITH T5OD MANUAL TRANSMISSION AND 3.8L ENGINE

TRANSMISSION—MANUAL—T5OD—3.8L ENGINE—LIGHT “CLICKING” AND/OR “GRINDING” NOISE—VEHICLES BUILT FROM 8/11/95 THROUGH 9/25/95

96-04-06

COOLING SYSTEM—COOLANT LEAK FROM UPPER RADIATOR HOSE—VEHICLES BUILT FROM 8/14/95 THROUGH 11/8/95 WITH 3.8L ENGINE

LEAKS—COOLING SYSTEM—COOLANT LEAKFROM UPPER RADIATOR HOSE—VEHICLES BUILTFROM 8/14/95 THROUGH 11/8/95 WITH 3.8LENGINE

96-06-05

TRANSMISSION—4R70W—#9 THRUST BEARING—SERVICE TIP

96-07-02

LOCKS—NEW DESIGN LOCKSETS HAVE BEEN INSTALLED ON CERTAIN TRIAL VEHICLES—CARS REFERENCED—SERVICE TIP

96-07-11

TRANSMISSION—4R70W—SPECIAL SELECTION PROCEDURE FOR LOW SERVO PISTON—SERVICE TIP
TRANSMISSION—4R70W—UNIQUE CASE WITH
LOW/REVERSE SPACER—SERVICE TIP

96-10-06

NEW GENERATION STAR (NGS) TESTER—INCORRECT INFORMATION DISPLAYED DURING DIAGNOSTIC MONITORING TEST RESULTS—VEHICLES WITH ON-BOARD DIAGNOSTICS (OBD) II

96-10-07

FUEL—CALIFORNIA REFORMULATED GASOLINE (CARFG)—SERVICE TIP

96-11-01

LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

96-12-05

ANTI THEFT—DIAGNOSTIC PROCEDURES—SERVICE TIP

96-12-09

NOISE—“CHATTER” DURING TIGHT TURNS OR TURNS AFTER AN EXTENDED PERIOD OF HIGHWAY DRIVING—TRACTION-LOK
DIFFERENTIAL—7.5 AND 8.8 INCH RING GEAR
REAR AXLES
AXLE—NEW SERVICE KIT AVAILABLE FOR
TRACTION-LOK DIFFERENTIAL—7.5 AND 8.8 INCH
RING GEAR
AXLE—TRACTION-LOK DIFFERENTIAL—7.5 AND
8.8 INCH RING GEAR—“CHATTER” NOISE DURING
TIGHT TURNS OR TURNS AFTER AN EXTENDED
PERIOD OF HIGHWAY DRIVING

96-14-08

ENGINE—NOISE—“SQUEAL” NOISE COMING FROM FEAD DURING COLD START AT TEMPERATURES BELOW -7 DEGREES C (20 DEGREES F)—4.6L VEHICLES

NOISE—“SQUEAL” DURING COLD START ATTEMPERATURES BELOW -7 DEGREES C (20
DEGREES F)—FEAD IDLER PULLEY AND/OR FEAD
TENSIONER ASSEMBLY—4.6L VEHICLES

96-14-09

BELT—FRONT END ACCESSORY DRIVE (FEAD) “SQUEAL/HOOT”—DURING COLD START-UP AFTER COLD SOAK BELOW -18 DEGREES C (0 DEGREES F)

NOISE—“SQUEAL/HOOT” FROM FRONT END
ACCESSORY DRIVE (FEAD) AREA—DURING COLD
START-UP AFTER COLD SOAK BELOW -18
DEGREES C (0 DEGREES F)

96-15-06

AIR CONDITIONING–FILTERING REFRIGERANT–SYSTEM FLUSHING–TRACER DYE–LEAK TESTING–O-RING TOOL–TSB REPLUBLICATION TO INCLUDE LATEST MODEL YEAR

96-16-01

SUSPENSION—FRONT—“RATTLE” NOISE—MOST NOTICEABLE IN COLD TEMPERATURES—VEHICLES BUILT FROM 8/14/95 THROUGH 1/19/96
NOISE—“RATTLE” FROM FRONT SUSPENSION—
MOST NOTICEABLE IN COLD TEMPERATURES—
VEHICLES BUILT FROM 8/14/95 THROUGH 1/19/96

96-17-09

SUSPENSION—FRONT—“RATTLE” NOISE—MOST NOTICEABLE IN COLD TEMPERATURES—VEHICLES BUILT FROM 8/14/95 THROUGH 1/19/96
NOISE—“RATTLE” FROM FRONT SUSPENSION—MOST NOTICEABLE IN COLD TEMPERATURES—
VEHICLES BUILT FROM 8/14/95 THROUGH 1/19/96

96-20-07

96-20-08

AIR CONDITIONING—NEW O-RING APPLICATIONS—THICKER O-RINGS FOR SPRING LOCK FITTINGS—SERVICE TIP
AIR CONDITIONING—SPRING LOCK COUPLING CLEANING PROCEDURE—SERVICE TIP

96-22-05

MASS AIR FLOW SENSOR—REPLACEMENT AS AN ASSEMBLY—SERVICE TIP

96-23-07

ENGINE—3.8L—OIL LEAK AT #4 FRONT COVER/WATER PUMP STUD—VEHICLES BUILT THROUGH 1/10/96

96-24-06

WIRING—ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS

96-24-09

TORQUE CONVERTER—LEAK TEST PROCEDURE—SERVICE TIP

96-25-03

INTERIOR TRIM—CENTER CONSOLE—AVAILABILITY OF GAP HIDER FOR CENTER CONSOLE—VEHICLES BUILT FROM 6/1/96

96-25-12

AIR CONDITIONING—AIR CONDITIONING SHUTS OFF IN HIGH AMBIENT TEMPERATURES AND VEHICLE MAY OVERHEAT—4.6L AND GT OR COBRA

COOLING SYSTEM—OVERHEATING AND/OR
VEHICLE GOING INTO THERMO PROTECTION
MODE—VEHICLES WITH 4.6L ENGINE AND GT OR
COBRA

96-26-08

BLOWER MOTOR—INTERMITTENT OR INOPERATIVE—TEMPERATURES AT OR BELOW 0 96-26-8DEGREES C (32 DEGREES F)

96-26-12

TRANSAXLE—TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEMCLEANING PROCEDURES—SERVICE TIP

TRANSMISSION—TORQUE CONVERTER
REPLACEMENT GUIDELINES AND TORQUE
CONVERTER/TRANSMISSION COOLING SYSTEM
CLEANING PROCEDURES—SERVICE TIP

97-05-06

ODOMETER—ODOMETER AND TRIP METER STICK—WILL NOT OPERATE AND/OR “CLICKING” NOISE—VEHICLES BUILT 3/14/96 THROUGH 9/13/96
NOISE—“CLICKING” NOISE FROM ODOMETER OR
TRIP METER—INOPERATIVE—VEHICLES BUILT
3/14/96 THROUGH 9/13/96

97-08-06

MALFUNCTION INDICATOR LAMP (MIL)—DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307,AND/OR P0308 STORED IN MEMORY

LAMP—MALFUNCTION INDICATOR LAMP (MIL)ILLUMINATES—DIAGNOSTIC TROUBLE CODES(DTCS) P0300, P0301, P0302, P0303, P0304, P0305,P0306, P0307, AND/OR P0308 STORED IN MEMORY

97-09-05

LONG CRANK—STICKING IDLE AIR CONTROL (IAC) VALVE—VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96

STALL—AFTER STARTING WHEN ENGINEALLOWED TO SOAK FROM 1-4 HOURS—STICKING
IDLE AIR CONTROL (IAC) VALVE—VEHICLES
BUILT FROM 11/1/94 THROUGH 3/30/96

97-09-07

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED—DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305,
P0306, P0307, P0308—NO DRIVEABILITY
CONCERNS—4.6L 2V ENGINES ONLY

LAMP—MALFUNCTION INDICATOR LAMP (MIL)ILLUMINATED—DIAGNOSTIC TROUBLE CODES
(DTCS) P0300, P0301, P0302, P0303, P0304, P0305,
P0306, P0307, P0308—NO DRIVEABILITY
CONCERNS—4.6L 2V ENGINES ONLY

POWERTRAIN CONTROL MODULE (PCM)—
REPROGRAM—4.6L 2V ENGINES ONLY

97-09-08

POWERTRAIN CONTROL MODULE—REPROGRAM POWERTRAIN CONTROL MODULE (PCM)—SERVICE PROCEDURES—SERVICE TIP

97-10-04

ENGINE COOLING FAN—MODULE COMPONENT SERVICE INFORMATION
COOLING FAN—MODULE COMPONENT SERVICE
INFORMATION

97-10-05

AIR CONDITIONING—COMPRESSOR FAILURE—INSUFFICIENT AMOUNT OF REFRIGERANT OIL AIR CONDITIONING—LACK OF COOLING—
INSUFFICIENT AMOUNT OF REFRIGERANT OIL
MAY CAUSE COMPRESSOR FAILURE

97-11-11

TRANSMISSION—4R70W—ERRATIC OR PROLONGED 1-2 SHIFT

TRANSMISSION—AODE—ERRATIC OR PROLONGED 1-2 SHIFT

97-15-05

AIR CONDITIONING—OIL REFILL CAPACITY CHART—SERVICE TIP

97-19-04

BRAKES—BRAKE AND ROTOR SERVICE TIPS

97-21-10

TRANSMISSION—4R70W—NEW DESIGN ENHANCEMENTS FOR 1998 VEHICLES

TRANSMISSION—4R70W—NEW ONE-WAY CLUTCH (OWC) TO SERVICE AT THE INTERMEDIATEPOSITION

97-22-01

DELTA PRESSURE FEEDBACK EGR (DPFE)—DIAGNOSTIC TIPS

97-24-01

LEAKS WATER—DURING HEAVY RAIN AND/OR WHEN GOING THROUGH CAR WASH—CONVERTIBLE TOP VEHICLES ONLY

97-24-13

REMOTE KEYLESS ENTRY (RKE)—DIAGNOSTIC SERVICE TIPS

97-24-15

LAMP—LOW OIL INDICATOR LAMP ILLUMINATION—4.6L VEHICLES

OIL—LOW OIL INDICATOR LAMP ILLUMINATION—
4.6L VEHICLES

97-25-05

BLOWER MOTOR—“CHIRPING” OR “SQUEAKING” FROM BLOWER MOTOR AT LOW SPEEDS

NOISE—“CHIRPING” OR “SQUEAKING” FROM BLOWER MOTOR AT LOW SPEEDS

98-07-04

98-12-05

98-17-18

MOULDINGS—ROCKER PANEL—LOOSE

98-20-10

EXHAUST SYSTEM—LOOSE CATALYST OR MUFFLER HEAT SHIELDS

NOISE—“BUZZING” OR “RATTLING”—LOOSE
CATALYST OR MUFFLER HEAT SHIELDS

98-20-18

FRONT END ACCESSORY DRIVE (FEAD) BELT—BELT NOISE, DAMAGE, AND/OR BELT COMES OFF—VEHICLES WITH 4.6L ENGINE AND MANUALTRANSMISSION

98-22-02

CLUTCH—VIBRATION/NOISE FELT IN CLUTCH PEDAL WHEN LIGHTLY TOUCHING CLUTCH PEDAL

98-23-10

MASS AIR FLOW (MAF)—SENSOR CONTAMINATION—SERVICE TIP

98-23-12

TRANSMISSION—4R44E—DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY

TRANSMISSION—4R55E—DIAGNOSTIC TROUBLECODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY

TRANSMISSION—4R70W—DIAGNOSTIC TROUBLE
CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY

TRANSMISSION—5R55E—DIAGNOSTIC TROUBLE
CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY

TRANSMISSION—AX4N—DIAGNOSTIC TROUBLE
CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY

TRANSMISSION—AX4S—DIAGNOSTIC TROUBLE
CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY

TRANSMISSION—E4OD—DIAGNOSTIC TROUBLE
CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY

98-25-03

GLASS—FRONT WINDOW MAY TRAVEL BEYOND THE UPSTOP AND OUT OF THE GLASS RUN

99-02-03

WATER LEAKS—WINDSHIELD SEALING—SERVICE TIP

WINDSHIELD—SEALING—SERVICE TIP

99-04-03

REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS)—OUT-OF-VEHICLE—EEC V VEHICLES ONLY

99-08-15

INTERIOR TRIM—DOOR TRIM PANEL REPLACEMENT—SERVICE TIP

99-10-01

BODY—DUST INTRUSION INTO LUGGAGE COMPARTMENT

WATER LEAK—EVIDENCE OF WATER LEAK INTO
LUGGAGE COMPARTMENT

NOISE—EXCESSIVE ROAD NOISE HEARD FROM
REAR WHEEL AREA

99-11-01

NOISE—TSB Special For Noise/Vibration/Harshness
VIBRATION—TSB Special For Noise/Vibration/Harshness

99-14-07

CALIBRATION INFORMATION—VEHICLES BUILT THROUGH 1/29/1999—APPLICABLE ENGINES ARE 2.0L, 2.5L, 3.0L, 3.4L, 3.8L, 4.0L, 4.2L, 4.6L, 5.0L, 5.4L, 6.8L, AND 7.3L—SERVICE TIP

99-18-05

TRANSMISSION CONTROL INDICATOR LAMP (TCIL)—TCIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0782 STORED IN MEMORY—VEHICLES BUILT BETWEEN 3/15/1997
AND 12/31/1998 AND WITH 4R70W TRANSMISSION

TRANSMISSION—4R70W—DELAYED OR NO 2-3
UPSHIFT—VEHICLES BUILT BETWEEN 3/15/1997
AND 12/31/1998

99-19-07

LAMP—INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION—DIAGNOSTIC TROUBLE CODES (DTCS) P0741, P0750, P0755, AND P1746 MAY BE STORED IN MEMORY—
VEHICLES BUILT FROM 8/1/1998 THROUGH 5/1/1999 WITH 4R70W TRANSMISSION

LAMP—INTERMITTENT TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ILLUMINATION—DIAGNOSTIC TROUBLE CODES (DTCS) P0741, P0750, P0755, AND P1746 MAY BE STORED IN
MEMORY—VEHICLES BUILT FROM 8/1/1998 THROUGH 5/1/1999 WITH 4R70W TRANSMISSION

TRANSMISSION—4R70W—INTERMITTENT TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ILLUMINATION—DIAGNOSTIC TROUBLE CODES (DTCS) P0741, P0750, P0755, AND P1746 MAY BE STORED IN MEMORY—VEHICLES BUILT FROM 8/1/1998 THROUGH 5/1/1999

99-20-07

COOLING SYSTEM—3.8L—UNDETERMINED LOSS OF COOLANT

COOLING SYSTEM—4.2L—UNDETERMINED LOSSOF COOLANT

ENGINE—3.8L—ENGINE OIL CONTAMINATED WITHCOOLANT

ENGINE—4.2L—ENGINE OIL CONTAMINATED WITHCOOLANT

99-21-08

BODY—“CREAKING” NOISE FROM LH REAR QUARTER AREA—CONVERTIBLES ONLY

NOISE—“CREAKING” FROM LH REAR QUARTER AREA—CONVERTIBLES ONLY

99-22-05

CONVERTIBLE TOP—IMPROPER FIT OF CONVERTIBLE TOP BOOT

99-22-06

NOISE—“POPPING” OR “OIL CANNING” NOISE FROM DRIVER’S FOOTWELL AREA

99-23-04

MALFUNCTION INDICATOR LAMP (MIL)—DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455—NO DRIVEABILITY CONCERNS

99-24-02

LOCKS—REPLACE AND/OR REPAIR ANY LOCK COMPONENT—AVAILABILITY OF INDIVIDUAL LOCKS